Download or read book Synthesis and Characterization of Zintl Phases for Thermoelectric Applications written by Tanghong Yi and published by . This book was released on 2012 with total page pages. Available in PDF, EPUB and Kindle. Book excerpt: A high efficiency thermoelectric material requires being a "phonon glass -electron crystal". Zintl phase compounds can be engineered to combine a "phonon glass" with an "electron crystal" by selectively doping the system to optimize the electronic properties. Current research on thermoelectrics is concentrated on (I) chemical or physical changes to improve the existing materials such as doping and reducing particle size to nano-size and (II) new materials with superior thermoelectric properties. Chapters 2 and 3 have been focused on tuning the transport properties of existing materials to improve the thermoelectric performance. In chapters 4 and 5, new Zintl phases have been synthesized and investigated with respect to their thermoelectric properties. In chapter 2, silicon nanoparticles embedded Mg2Si/xSi nanocomposites have been synthesized at 623 K from MgH2 and Bi containing Si nanoparticle powders. This synthetic route avoids the production of oxides and lowers the formation temperature of Mg2Si. It also provides a route to homogeneously mixed Si nanoparitcles within a Mg2Si matrix. Powder X-ray diffraction (XRD), thermogravimetry/differential scanning calorimetry (TG/DSC), electron microprobe analysis (EMPA), and scanning transmission electron microscopy (STEM) are applied to characterize the phase and micro-structure. Thermoelectric properties measurements indicate that the thermal conductivity is reduced by a small amount of Si nano-inclusions, which is in agreement of our theoretical calculations. A dimensionless figure of merit zT ~ 0.7 is obtained at 775 K for 1% Bi doped Mg2Si/x Si with x = 0 and 2.5 mol.%. In chapter 3, magnetic and transport properties of a series of Te doped Yb14MnSb11 samples prepared by Sn flux method have been studied. Increasing amounts of Te increases the saturation moment of Yb14MnSb11−(x)Te(x) and magnetoresistence effect. Both Seebeck coefficient and electrical resistivity increase with increasing amount of Te as a result of decreasing carrier concentration. Approximately 12% improvement of zT has achieved for x = 0.07 at 1240 K. Thermoelectric properties of the compounds Yb11MSb9 (M = Ga, In) via self-flux synthesis, closely structure related to Yb14MnSb11, have been investigated in chapter 4. Particularly low lattice thermal conductivity values, less than 0.6 W/m*K, are obtained for both compounds. The low lattice thermal conductivity suggests that Yb11MSb9 (M = Ga, In) has the potential for high thermoelectric efficiency at high temperature if charge carrier doping can be optimized. A two-step solid-state method is developed to fabricate two rare-earth containing ternary phosphides, Eu3Ga2P4 and Eu3In2P4, and their thermoelectric properties are investigated in chapter 5. The powder XRD and TG-DSC are employed to characterize the phase purity and thermal stability. Electronic structures of both compounds are calculated and provide band-gaps of 0.60 and 0.29 eV for Eu3Ga2P4 and Eu3In2P4, respectively. Transport properties measurements suggest that these Zintl phosphides have the potential to be good high temperature thermoelectric materials with optimization of the charge carrier concentration by appropriate extrinsic dopants.